储罐外爆冲击波数值模拟及超压公式研究
CSTR:
作者:
基金项目:

国家自然科学基金青年科学基金资助项目(51408609);中央高校基本科研业务费专项资金资助项目(15CX02044A);中国石油大学(华东)学术硕士点建设项目(XWS130005)


Research on propagation rule and overpressure formula of blast shock wave outside storage tank
Author:
  • 摘要
  • | |
  • 访问统计
  • |
  • 参考文献 [14]
  • |
  • 相似文献
  • |
  • 引证文献
  • | |
  • 文章评论
    摘要:

    为研究储罐外爆冲击波的传播规律和对储罐安全性的影响,应用软件LS-DYNA建立炸药-储罐的数值模型,并进行空爆数值计算。研究分析储罐外爆冲击波超压的衰减关系和罐体的动力响应,与经验公式的对比验证了模型的可信性,并结合经验公式平均值对数值模拟结果做了进一步修正。结果表明:冲击波运动到迎爆面中心后,外罐主应力在10 ms时迅速达到最大值,随后主应力值迅速减小,并不断振荡;迎爆面中心首先产生较大的拉应力,混凝土外罐的破坏属于脆性破坏;比例距离大于1时,现有超压计算公式拟合超压的衰减规律误差较小,比例距离小于1时,超压计算公式误差较大,修正后的超压计算公式可为储罐抗爆设计提供参考。

    Abstract:

    To study the propagation rule of blast shock wave outside tank and its impact on the safety of storage tank, the software LS-DYNA was used to build numerical model of dynamite-storage tank, and the air blast numerical calculation was performed. The study analyzed the attenuation relation of shock wave overpressure and the dynamic response of the tank. The reliability of the model was verified by contrast with the empirical formula. And the further amendment for numerical simulation results was made. The results are as follows: When shock wave moves to burst surface center, principal stress in 10ms quickly reaches maximum value, and then decreases rapidly and continuously oscillated; The facing blasting center first produces larger tensile stress, the destruction of concrete tank belongs to brittle failure; When the proportion distance is greater than 1, overpressure formula can better fit the attenuation law of overpressure; While the proportion distance is less than 1, the error of the overpressure formula is large. The amended overpressure calculation formula can be used as a reference tank blast-resistant design.

    参考文献
    [1] 李晓勇,崔村燕,陈景鹏,等.LS-DYNA软件开展爆炸冲击波计算时需考虑的问题[J].装备学院学报,2014,25(4):79-84.
    [2] GB6722-2011,爆破安全规程[S].
    [3] BRODE H L.Blast wave from a spherical charge[J].Phys Fluids,l959,2(2):217.
    [4] 亨利奇.爆炸动力学及其应用[M].熊建国译.北京:科学出版社,1987.
    [5] SADOVSKYI M A.Mechanical action of air shock waves of explosion, based on experimental data[M].Moscow:Izd Akad Nauk SSSR,1952.
    [6] BAKER W E.Explosions in air[M].Austin:University of Texas Press,1974.
    [7] WU Chengqing,HAO Hong.Modeling of simultaneous ground shock and from surface Explosions[J].Int. J. Impact Eng.,2005,31(6):699-717.
    [8] 管友海,贾娟娟,林楠,等.大型LNG储罐液固耦合模态分析[J].当代化工,2015,44(1):148-151.
    [9] 吴彦捷,高轩能.爆炸冲击波数值模拟及超压计算公式修正[J].华侨大学学报:自然科学版,2014,35(3):321-326.
    [10] 吴媛媛,宋振森.挡墙后爆炸冲击波绕流现象研究[J].河北工程大学学报:自然科学版,2014,31(2):9-14.
    [11] 申祖武,张耀辉,谢伟平,等.爆炸冲击波的环流效应数值模拟研究[J].武汉理工大学学报,2006,28(2):42-44.
    [12] 仲倩,王伯良,黄菊,等.TNT空中爆炸超压的相似律[J].火炸药学报,2008,33(2):32-35.
    [13] 杨鑫,石少卿,程鹏飞.空气中TNT爆炸冲击波超压峰值的预测及数值模拟[J].爆破,2008,25(1):15-19.
    [14] 董桂旭,杜茂华,黄雪峰.某型炸药的冲击波超压峰值计算公式参数的修正[J].海军航空工程学院学报,2010,25(5):542-544.
    相似文献
    引证文献
引用本文

唐兴亮,管友海,贾娟娟,西文喜.储罐外爆冲击波数值模拟及超压公式研究[J].河北工程大学自然版,2016,33(3):104-108

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2016-04-20
  • 在线发布日期: 2016-10-27
文章二维码